Forgotten Era Speed Hill Climb 350 Morini MKII

Show us your projects and restorations

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby 72degrees » 20 Aug 2017 16:12

One or two little settling down jobs done. The front header pipe was a bit loose and was also starting to pull out of the silencer joint. All tightened up but I really must tweak the 2:1 properly before next season to get better ground clearance on the left hand side.

Gear linkage adjusted to suit my snazzy new Alpinestars boots.

I discovered the plain clutch plates were pitted with rust (despite being new last November) so I've cleaned them up and the clutch is now not so binary (the shimming was still perfect), but I will borrow the 375 stack for the next event anyway. Riding that yesterday reminded me how sweet the clutch is.

Still starting OK on the NLM pickup but it requires more than the one kick that the 375 does. I keep meaning to dig out a pair of the 350 Marzocchi rear shockers I have in the shed to compare length and stiffness of springing. I could do with them being longer but a bit more softly sprung than the Konis currently on it.

So nothing to do now except wait for Manor Farm and Wiscombe in September. Time to get the GFR an MoT.
User avatar
72degrees
 
Posts: 863
Joined: 31 Aug 2007 21:24
Location: West Midlands

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby 72degrees » 08 Sep 2017 11:09

Well the FE MKII is starting reasonably well now on the NLM pickup. Needs a starter jet open for a while to warm up though. I thought I'd give it a last manometer balance before this weekend and was gratified to find it spot on, despite having tweaked the throttle stop screws by ear to get a consistent idle while fiddling with the ignition timing. It may be my imagination but perhaps the accurate (by my standards of accurate) timing on both cylinders is assisting with the balance. I think I'll pop the strobe in to the van anyway to possibly do bedding in checks on that - though the weather forecast doesn't sound to good for outdoor fettling. We will see how it feels on the first practice run.

I dug out the (350) Marzocchis to find that they are shorter than the Konis. No wonder the steering is nice and sharp. So they are staying on to keep ground clearance until I can adjust the rear header pipe.

I'm also going to ride the KTM for a change to make the diesel cost for a 350 mile round trip worth it. Two events on two bikes means - wow, a total of possibly as much as 10 minutes riding!
User avatar
72degrees
 
Posts: 863
Joined: 31 Aug 2007 21:24
Location: West Midlands

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby Ming » 08 Sep 2017 13:06

72degrees wrote:...I'm also going to ride the KTM for a change to make the diesel cost for a 350 mile round trip worth it. Two events on two bikes means - wow, a total of possibly as much as 10 minutes riding!

Well, you could always ride them more slowly... :wink:

Good luck, keep the black side track side down.
User avatar
Ming
 
Posts: 193
Joined: 01 Aug 2014 16:32
Location: Central France

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby 72degrees » 10 Sep 2017 20:53

Ming wrote:Good luck, keep the black side track side down.


Not so much black as mud coloured. I 've never seen the paddock at Wiscombe so muddy in <calculates> 37 years of going there.

Well at least it carried on starting OK, but if there's a performance boost from the NLM pickup I can't say I noticed it. Not ideal conditions to be fair.

Possibly the slowest ever runs up that hill on any bike. Still, I got to the top four times on the wee vee and at one stage I was only a second or so quicker on the KTM - then it dried up a bit and I just pointed and squirted the two stroke. The new carb on the KTM shows promise but it's not quite right - a good job the lad wasn't riding it.

The 'Vincent Straight' handlebars are perfect, so they will be staying on.

Whether to bother with Hartland Quay next month - now that is the question.
User avatar
72degrees
 
Posts: 863
Joined: 31 Aug 2007 21:24
Location: West Midlands

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby 72degrees » 11 Sep 2017 06:24

Very sedate at Manor Farm. Note the two stroke finger hovering over the clutch lever. Old habits die hard and to be fair I had just jumped of the KTM.

Manor Morini.jpg
Manor Morini.jpg (284.8 KiB) Viewed 98 times
User avatar
72degrees
 
Posts: 863
Joined: 31 Aug 2007 21:24
Location: West Midlands

Re: Forgotten Era Speed Hill Climb 350 Morini MKII

Postby Butch » 11 Sep 2017 16:55

Looking good. I'm fortunate to have a few bikes, but whenever I'm tramping on with the H1 the left hand figures start to hover expectantly. Mostly subconscious - before I notice I'm doing it. And it's the only bike I find myself doing it on.
Butch
 
Posts: 73
Joined: 15 Oct 2016 16:47
Location: Mid Essex

Previous

Return to Projects

Who is online

Users browsing this forum: No registered users and 1 guest

cron